ATV212HU22N4
درایو آلتیوار212 اشنایدر - 2.2کیلو وات - 3hp - 480V - 3ph - EMC - IP21
variable speed drive ATV212 - 2.2kW - 3hp - 480V - 3ph - EMC - IP21
×
![]()
مشخصات کامل
گروه محصول
Altivar 212
range of product
نوع محصول یا مولفه تجهیزات
Variable speed drive
product or component type
نام کوتاه دستگاه
ATV212
device short name
کاربرد محصول
Asynchronous motors
product destination
برنامه خاص محصول
Pumps and fans in HVAC
product specific application
سبک مونتاژ
With heat sink
assembly style
تعداد فازهای شبکه
3 phases
network number of phases
قدرت موتور کیلووات
2.2 kW
motor power kW
قدرت موتور اسب بخار
3 hp
motor power hp
ولتاژ منبع تغذیه
380...480 V - 15...10 %
[Us] rated supply voltage
محدوده ساپورت ولتاژ
323…528 V
supply voltage limits
فرکانس تأمین
50...60 Hz - 5...5 %
supply frequency
فیلتر EMC
Class C2 EMC filter integrated
EMC filter
جریان خط
3.6 A at 480 V4.6 A at 380 V
line current
توان ظاهری
3.9 kVA at 380 V
apparent power
خط سه بعدی
5 kA
prospective line Isc
جریان خروجی مداوم
5.1 A at 380 V5.1 A at 460 V
continuous output current
حداکثر جریان گذرا
5.6 A for 60 s
maximum transient current
فرکانس خروجی سرعت درایو
0.5…200 Hz
speed drive output frequency
فرکانس سوئیچ اسمی
12 kHz
nominal switching frequency
فرکانس سوئیچینگ
6...16 kHz adjustable12...16 kHz with derating factor
switching frequency
دامنه سرعت
1…10
speed range
دقت سرعت
+/- 10 % of nominal slip 0.2 Tn to Tn
speed accuracy
دقت گشتاور
+/- 15 %
torque accuracy
اضافه گشتاور گذرا
120 % of nominal motor torque +/- 10 % for 60 s
transient overtorque
مشخصات کنترل موتور ناهمزمان
Voltage/frequency ratio, automatic IR compensation (U/f + automatic Uo)Voltage/frequency ratio, 5 pointsFlux vector control without sensor, standardVoltage/frequency ratio - Energy Saving, quadratic U/fVoltage/frequency ratio, 2 points
asynchronous motor control profile
حلقه تنظیم
Adjustable PI regulator
regulation loop
جبران لغزش موتور
Not available in voltage/frequency ratio motor controlAdjustableAutomatic whatever the load
motor slip compensation
سیگنالینگ محلی
1 LED (red) for DC bus energized
local signalling
ولتاژ خروجی
<= power supply voltage
output voltage
ایزوله
Electrical between power and control
isolation
نوع کابل
Without mounting kit: 1 wire(s)IEC cable at 45 °C, copper 90 °C / XLPE/EPRWithout mounting kit: 1 wire(s)IEC cable at 45 °C, copper 70 °C / PVCWith UL Type 1 kit: 3 wire(s)UL 508 cable at 40 °C, copper 75 °C / PVC
type of cable
اتصال برق
VIA, VIB, FM, FLA, FLB, FLC, RY, RC, F, R, RES: terminal 2.5 mm² / AWG 14L1/R, L2/S, L3/T: terminal 6 mm² / AWG 10
electrical connection
گشتاور محکم
1.3 N.m, 11.5 lb.in (L1/R, L2/S, L3/T)0.6 N.m (VIA, VIB, FM, FLA, FLB, FLC, RY, RC, F, R, RES)
tightening torque
ساپورت
Internal supply for reference potentiometer (1 to 10 kOhm): 10.5 V DC +/- 5 %, <10 A, protection type: overload and short-circuit protectionInternal supply: 24 V DC (21…27 V), <200 A, protection type: overload and short-circuit protection
supply
تعداد ورودی آنالوگ
2
analogue input number
نوع ورودی آنالوگ
VIA switch-configurable voltage: 0...10 V DC 24 V max, impedance: 30000 Ohm, resolution 10 bitsVIB configurable voltage: 0...10 V DC 24 V max, impedance: 30000 Ohm, resolution 10 bitsVIB configurable PTC probe: 0...6 probes, impedance: 1500 OhmVIA switch-configurable current: 0...20 mA, impedance: 250 Ohm, resolution 10 bits
analogue input type
مدت زمان نمونه گیری
2 ms +/- 0.5 ms F discrete2 ms +/- 0.5 ms R discrete2 ms +/- 0.5 ms RES discrete3.5 ms +/- 0.5 ms VIA analog22 ms +/- 0.5 ms VIB analog
sampling duration
زمان پاسخ
FM 2 ms, tolerance +/- 0.5 ms for analog output(s)FLA, FLC 7 ms, tolerance +/- 0.5 ms for discrete output(s)FLB, FLC 7 ms, tolerance +/- 0.5 ms for discrete output(s)RY, RC 7 ms, tolerance +/- 0.5 ms for discrete output(s)
response time
دقت
+/- 0.6 % (VIA) for a temperature variation 60 °C+/- 0.6 % (VIB) for a temperature variation 60 °C+/- 1 % (FM) for a temperature variation 60 °C
accuracy
خطای خطی
VIA: +/- 0.15 % of maximum value for inputVIB: +/- 0.15 % of maximum value for inputFM: +/- 0.2 % for output
linearity error
شماره خروجی آنالوگ
1
analogue output number
نوع خروجی آنالوگ
FM switch-configurable voltage 0...10 V DC, impedance: 7620 Ohm, resolution 10 bitsFM switch-configurable current 0...20 mA, impedance: 970 Ohm, resolution 10 bits
analogue output type
تعداد خروجی دیجیتال
2
discrete output number
نوع خروجی دیجیتال
Configurable relay logic: (FLA, FLC) NO - 100000 cyclesConfigurable relay logic: (FLB, FLC) NC - 100000 cyclesConfigurable relay logic: (RY, RC) NO - 100000 cycles
discrete output type
حداقل جریان سوئیچینگ
3 mA at 24 V DC for configurable relay logic
minimum switching current
حداکثر جریان سوئیچینگ
5 A at 250 V AC on resistive load - cos phi = 1 - L/R = 0 ms (FL, R)5 A at 30 V DC on resistive load - cos phi = 1 - L/R = 0 ms (FL, R)2 A at 250 V AC on inductive load - cos phi = 0.4 - L/R = 7 ms (FL, R)2 A at 30 V DC on inductive load - cos phi = 0.4 - L/R = 7 ms (FL, R)
maximum switching current
نوع ورودی گسسته
F programmable 24 V DC, with level 1 PLC, impedance: 4700 OhmR programmable 24 V DC, with level 1 PLC, impedance: 4700 OhmRES programmable 24 V DC, with level 1 PLC, impedance: 4700 Ohm
discrete input type
منطق ورودی گسسته
Positive logic (source) (F, R, RES), <= 5 V (state 0), >= 11 V (state 1)Negative logic (sink) (F, R, RES), >= 16 V (state 0), <= 10 V (state 1)
discrete input logic
رمپ های شتاب و کاهش سرعت
Automatic based on the loadLinear adjustable separately from 0.01 to 3200 s
acceleration and deceleration ramps
ترمز در حالت سکون
By DC injection
braking to standstill
نوع محافظت
Overheating protection: driveThermal power stage: driveShort-circuit between motor phases: driveInput phase breaks: driveOvercurrent between output phases and earth: driveOvervoltages on the DC bus: driveBreak on the control circuit: driveAgainst exceeding limit speed: driveLine supply overvoltage and undervoltage: driveLine supply undervoltage: driveAgainst input phase loss: driveThermal protection: motorMotor phase break: motorWith PTC probes: motor
protection type
قدرت دی الکتریک
3535 V DC between earth and power terminals5092 V DC between control and power terminals
dielectric strength
مقاومت عایق
>= 1 mOhm 500 V DC for 1 minute
insulation resistance
فرکانس رزولیشن
Display unit: 0.1 HzAnalog input: 0.024/50 Hz
frequency resolution
پروتکل پورت ارتباطی
BACnetLonWorksModbusMETASYS N2APOGEE FLN
communication port protocol
نوع اتصال دهنده
1 open style1 RJ45
connector type
رابط فیزیکی
2-wire RS 485
physical interface
قاب انتقال
RTU
transmission frame
نرخ انتقال
9600 bps or 19200 bps
transmission rate
قالب داده
8 bits, 1 stop, odd even or no configurable parity
data format
نوع پلاریته
No impedance
type of polarization
تعداد آدرسها
1…247
number of addresses
سرویس ارتباطی
Write single register (06)Read device identification (43)Time out setting from 0.1 to 100 sRead holding registers (03) 2 words maximumWrite multiple registers (16) 2 words maximumMonitoring inhibitable
communication service
آپشن کارت
Communication card for LonWorks
option card
موقعیت عملیاتی
Vertical +/- 10 degree
operating position
عرض
107 mm
width
ارتفاع
143 mm
height
عمق
150 mm
depth
وزن خالص
2 kg
net weight
اتلاف توان در W
103 W
power dissipation in W
جریان هوا
35 m3/h
air flow
عملکرد
Mid
functionality
برنامه خاص
HVAC
specific application
درجه IP محافظت
IP21
IP degree of protection
انتخاب برنامه درایو سرعت متغیر
Building - HVAC Compressor for scrollBuilding - HVAC FanBuilding - HVAC Pump
Variable speed drive application selection
محدوده قدرت موتور AC-3
2.2…3 kW at 380…440 V 3 phases2.2…3 kW at 480…500 V 3 phases
Motor power range AC-3
نوع استارت موتور
Variable speed drive
motor starter type
سازگاری الکترومغناطیسی
Electrostatic discharge immunity test level 3 conforming to IEC 61000-4-2Radiated radio-frequency electromagnetic field immunity test level 3 conforming to IEC 61000-4-3Electrical fast transient/burst immunity test level 4 conforming to IEC 61000-4-41.2/50 µs - 8/20 µs surge immunity test level 3 conforming to IEC 61000-4-5Conducted radio-frequency immunity test level 3 conforming to IEC 61000-4-6Voltage dips and interruptions immunity test conforming to IEC 61000-4-11
electromagnetic compatibility
درجه آلودگی
3 conforming to IEC 61800-5-1
pollution degree
درجه IP محافظت
IP20 on upper part without blanking plate on cover conforming to EN/IEC 61800-5-1IP20 on upper part without blanking plate on cover conforming to EN/IEC 60529IP21 conforming to EN/IEC 61800-5-1IP21 conforming to EN/IEC 60529IP41 on upper part conforming to EN/IEC 61800-5-1IP41 on upper part conforming to EN/IEC 60529
IP degree of protection
مقاومت در برابر لرزش
1.5 mm (f= 3…13 Hz) conforming to EN/IEC 60068-2-61 gn (f= 13…200 Hz) conforming to EN/IEC 60068-2-8
vibration resistance
مقاومت در برابر ضربه
15 gn for 11 ms conforming to IEC 60068-2-27
shock resistance
ویژگی محیطی
Classes 3C1 conforming to IEC 60721-3-3Classes 3S2 conforming to IEC 60721-3-3
environmental characteristic
میزان نویز
51 dB conforming to 86/188/EEC
noise level
ارتفاع عملیاتی
1000...3000 m limited to 2000 m for the Corner Grounded distribution network with current derating 1 % per 100 m<= 1000 m without derating
operating altitude
رطوبت نسبی
5…95 % without condensation conforming to IEC 60068-2-35…95 % without dripping water conforming to IEC 60068-2-3
relative humidity
دمای هوای محیط برای کار
-10…40 °C (without derating)40…50 °C (with derating factor)
ambient air temperature for operation
دمای هوای محیط برای ذخیره سازی
-25…70 °C
ambient air temperature for storage
استانداردها
IEC 61800-3EN 61800-5-1IEC 61800-3 environments 1 category C2EN 61800-3 environments 1 category C2EN 61800-3EN 61800-3 environments 2 category C3EN 61800-3 environments 1 category C1IEC 61800-3 environments 1 category C3IEC 61800-3 category C3IEC 61800-3 environments 2 category C1UL Type 1EN 61800-3 category C3EN 61800-3 environments 1 category C3EN 61800-3 category C2EN 61800-3 environments 2 category C2IEC 61800-3 environments 2 category C3EN 55011 class A group 1IEC 61800-3 environments 2 category C2EN 61800-3 environments 2 category C1IEC 61800-5-1IEC 61800-3 category C2IEC 61800-3 environments 1 category C1
standards
گواهینامه های محصول
CSANOM 117ULC-Tick
product certifications
علامت گذاری
CE
marking
نوع واحد بسته بندی 1
PCE
Unit Type of Package 1
تعداد واحدهای موجود در بسته 1
1
Number of Units in Package 1
وزن بسته 1
1.95 kg
Package 1 Weight
ارتفاع بسته 1
18 cm
Package 1 Height
عرض بسته 1
18.5 cm
Package 1 width
طول بسته 1
21.2 cm
Package 1 Length
وزن 2 بسته
66.03 kg
Package 2 Weight
وضعیت پیشنهاد پایدار
Green Premium product
Sustainable offer status
مقررات REACh
REACh Declaration
REACh Regulation
بخشنامه RoHS اتحادیه اروپا
Pro-active compliance (Product out of EU RoHS legal scope)
EU RoHS Declaration
EU RoHS Directive
بدون مرکوری
Yes
Mercury free
اطلاعات معافیت RoHS
Yes
RoHS exemption information
مقررات RoHS چین
China RoHS declaration
China RoHS Regulation
محیط زیست
Product Environmental Profile
Environmental Disclosure
مشخصات بخشنامه
End of Life Information
Circularity Profile
WEEE
The product must be disposed on European Union markets following specific waste collection and never end up in rubbish bins
WEEE
ضمانتنامه
18 months
Warranty
